马旭光, 李传友, 袁旭峰, 朱万斌, 王小芬, 程序, 崔宗均. 高含固率秸秆和牛粪混合物料发酵产甲烷工艺[J]. 农业工程学报, 2014, 30(14): 227-235. DOI: doi:10.3969/j.issn.1002-6819.2014.14.029
    引用本文: 马旭光, 李传友, 袁旭峰, 朱万斌, 王小芬, 程序, 崔宗均. 高含固率秸秆和牛粪混合物料发酵产甲烷工艺[J]. 农业工程学报, 2014, 30(14): 227-235. DOI: doi:10.3969/j.issn.1002-6819.2014.14.029
    Ma Xuguang, Li Chuanyou, Yuan Xufeng, Zhu Wanbin, Wang Xiaofen, Cheng Xu, Cui Zongjun. Fermentation technology for methane production using high solid content materials with straw and dairy manure[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2014, 30(14): 227-235. DOI: doi:10.3969/j.issn.1002-6819.2014.14.029
    Citation: Ma Xuguang, Li Chuanyou, Yuan Xufeng, Zhu Wanbin, Wang Xiaofen, Cheng Xu, Cui Zongjun. Fermentation technology for methane production using high solid content materials with straw and dairy manure[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2014, 30(14): 227-235. DOI: doi:10.3969/j.issn.1002-6819.2014.14.029

    高含固率秸秆和牛粪混合物料发酵产甲烷工艺

    Fermentation technology for methane production using high solid content materials with straw and dairy manure

    • 摘要: 该研究针对高含固率纤维质物料难以连续厌氧发酵、甲烷产率低的问题,利用所研制的一套能连续进出料、具有高有机负荷承载力的新型反应器,以玉米秸秆和牛粪为原料,通过调控搅拌强度和投料强度在反应器内建立了"分区发酵"体系,比较了3种高含固率(10%、15%和20%)物料在不同有机负荷下的甲烷容积产率,系统研究了物料含固率、搅拌强度和投料强度对"分区发酵"体系形成功能分区的高度、各功能区的pH值和甲烷容积产率的影响,旨在为纤维质物料产甲烷提供高效的发酵工艺和可靠的运行参数。结果表明,含固率为10%和15%的反应器,甲烷容积产率随有机负荷的增加而增加,平均甲烷体积分数稳定在52%左右,二者在有机负荷分别为13.44和20.17 kg/(m3·d)时,甲烷容积产率最高,分别为1.62和1.66 m3/(m3·d),在有机负荷分别为20.17和30.0 kg/(m3·d)时,甲烷产量明显下降;含固率为20%的反应器,甲烷容积产率随有机负荷的增加基本保持不变且较低(0.98 m3/(m3·d)),当有机负荷达到30.0 kg/(m3·d)时,发酵体系酸败,甲烷产量明显下降。双因素优化结果表明,当物料含固率为10%和15%、搅拌强度为6~12 h/d、投料强度为6.5~10 d时,发酵体系可形成高效的酸化区和产甲烷区,二者的高度之比为1.1~1.6:1,甲烷容积产率可达1.63~1.69 m3/(m3·d)。综上,该反应器可实现含固率为10%~20%的纤维质物料连续进出料,并在含固率为10%和15%时能高效、稳定地产甲烷,通过调控搅拌强度和进料强度能提高其甲烷容积产率。该发酵工艺有规模化应用的前景。

       

      Abstract: Abstract: Methane production from lignocellulosic feedstock through high solid anaerobic digestion is a huge potential technology. However, the shortage of an efficient reactor has become a major bottleneck in developing the technology. The continuous feeding and discharge of lignocellulosic feedstock with high solids is difficult to complete. Methane production from the feedstock is low in practice. Thus, it is important to develop a new reactor with efficient feeding and discharge feedstock equipments and improve methane production by an optimized operation process. Based on synthesizing the merits of a number of techniques home and abroad, a novel anaerobic reactor was designed in this study. The reactor had two spiral equipments to implement continuous feeding and discharge feedstock with high solid content and had a high bearing capability of organic loading rate (OLR) to improve methane production. In order to provide a technology and some reliable operating parameters to efficiently produce methane from lignocellulosic feedstock, the continuous anaerobic co-digestion tests were conducted at three total solid contents of 10%, 15% and 20% using corn stalk and dairy manure as feedstock. An integrated two-phase division digestion system was constructed by controlling stirring intensity (h/d) and feeding intensity (d). The methane volumetric production rate (MVPR) of different OLRs was compared. Effects of the total solid (TS) of feedstock, stirring, feeding intensity on height, pH of function divisions, and MVPR were discussed in detail. The results showed that function divisions, including the acidification division of upside and methanogenic division of underpart in the vertical reactor, were obviously formed when TS were 10% and 15%, MVPR gradually increased, and methane content stabilized around 52% with OLR increasing. The highest MVPR reached 1.62 and 1.66 m3/(m3·d) respectively when OLR was 13.44 kg/(m3·d) at 10% TS and 20.17 kg/(m3·d) at 15% TS. MVPR significantly decreased when OLR was 20.17 kg/(m3·d) and 30.0 kg/(m3·d), respectively, which might be caused by the accumulation of volatile fatty acids. MVPR stabilized around 0.98 m3/(m3·d) with OLR increasing, then it dramatically decreased and anaerobic digestion failed when OLR reached 30.0 kg/(m3·d) at 20% TS. The results of two factors interacting declared the highest MVPR at 1.63-1.69 m3/(m3·d) The efficient acidification division and methanogenic division were formed, and the height ratio of both was 1.1-1.6:1 when stirring intensity, feeding intensity, and TS were 6-12 h/d, 6.5-10 d, and 10%-15%, respectively. In summary, the process of continuous feeding and discharge at 10%-20% TS of lignocellulosic feedstock was feasible in the anaerobic digestion reactor. The reactor was more efficient and stable to produce methane at 10% and 15% TS compared to 20% TS, and MVPR could be improved by adjusting stirring intensity and feeding intensity. Therefore, this technology has a promising prospect for industrial scale application.

       

    /

    返回文章
    返回