王教领, 宋卫东, 金诚谦, 丁天航, 王明友, 吴今姬, 刘自畅. 杏鲍菇转轮除湿热泵干燥系统结构设计及工艺参数优化[J]. 农业工程学报, 2019, 35(4): 273-280. DOI: 10.11975/j.issn.1002-6819.2019.04.034
    引用本文: 王教领, 宋卫东, 金诚谦, 丁天航, 王明友, 吴今姬, 刘自畅. 杏鲍菇转轮除湿热泵干燥系统结构设计及工艺参数优化[J]. 农业工程学报, 2019, 35(4): 273-280. DOI: 10.11975/j.issn.1002-6819.2019.04.034
    Wang Jiaoling, Song Weidong, Jin Chengqian, Ding Tianhang, Wang Mingyou, Wu Jinji, Liu Zichang. Structural design and process parameter optimization of heat pump drying system of wheel dehumidification for Pleurotus eryngii[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2019, 35(4): 273-280. DOI: 10.11975/j.issn.1002-6819.2019.04.034
    Citation: Wang Jiaoling, Song Weidong, Jin Chengqian, Ding Tianhang, Wang Mingyou, Wu Jinji, Liu Zichang. Structural design and process parameter optimization of heat pump drying system of wheel dehumidification for Pleurotus eryngii[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2019, 35(4): 273-280. DOI: 10.11975/j.issn.1002-6819.2019.04.034

    杏鲍菇转轮除湿热泵干燥系统结构设计及工艺参数优化

    Structural design and process parameter optimization of heat pump drying system of wheel dehumidification for Pleurotus eryngii

    • 摘要: 为了实现农产品低湿节能干燥,分析了典型转轮除湿干燥模式,基于能耗高、结构不合理等问题,开展转轮热泵联合除湿干燥系统优化设计与试验研究,研制出转轮除湿热泵干燥机。为了检验并提高转轮除湿热泵干燥机的作业性能,该文以杏鲍菇为研究对象,以降低杏鲍菇色差、除湿能耗比,提高复水性为目标,运用Box-Benhnken 中心组合试验设计理论,对再生温度、干燥温度、转换点相对湿度影响其干燥品质与能耗的因素开展响应面试验。通过数据分析,建立了响应面模型,结合四维渲染图分析了上述3个考察指标受3个试验因素取值变化的影响机制,同时对各影响因素进行了综合优化与试验验证。结果表明,3个模型的R2均大于0.98,试验因素对干燥品质及能耗有较大影响,当再生温度87 ℃,干燥温度50 ℃,转换点相对湿度45%时,杏鲍菇复水比4.028,色差22.89,除湿能耗比(specific power consumption, SPC)2 633 kJ/kg,与预测绝对值误差均低于6个百分点。该研究为转轮除湿热泵干燥设备的设计及干燥工艺优化提供参考。

       

      Abstract: Common methods of drying have three ways: radiation, conduction and convection. Convective drying has been widely used due to its simple equipment and wide application range. The parameters that can be optimized are temperature, wind speed and humidity, but the temperature has an upper limit in each drying stage. Exceeding the upper limit will destroy the quality of agricultural products. It’s not conducive to sufficient heat exchange between wind and material if exceeding the optimum air volume. The humidity is unrestricted for most of the drying period. Low humidity can increase the drying rate and, so humidity is an ideal adjustment parameter. Wheel dehumidification is a common mode in solid dehumidification. However, the traditional wheel dehumidifier has problems such as high energy consumption and unreasonable structure, while heat pump has limited deep dehumidification capacity, but the energy saving effect. In view of the above problems, in this paper, we proposed a model of wheel dehumidifying and for the problems of high energy consumption and unsuitable for drying of agricultural products based on traditional structure of wheel dehumidifying, the optimization design of the dehumidifying structure and the dehumidification system was carried out. Firstly, a conversion mechanism was set up to solve the problem of reasonable conversion between fresh air and circulating air to realize energy-saving drying. Secondly, the surface cooler was replaced by an evaporator and a condenser was set up to recycle the energy. The heat released from the condenser was used to heat dry the inlet air or to regenerate the dehumidification wheel. In order to test and improve the performance of the wheel and heat pump combined dryer, in this paper, we took the sliced Pleurotus eryngii as the research object, and aimed to reduce the color difference of the Pleurotus eryngii, specific power consumption and improve the rehydration, using Box-Benhnken. In the central combined experimental design theory, we carried out three-factor and three-level response surface tests on three factors that affected the drying quality and energy consumption, such as regeneration temperature, dry temperature and conversion point relative humidity. Data analysis was carried out and the response surface mathematical model was established. The four-dimensional renderings was used to analyze the influence mechanism of the above three indicators on the changes of the three test factors. The results showed that the R2 was near to 1and the test factors had a great influence on the drying quality and energy consumption. The order of importance of each factor to rehydration was dry temperature > regeneration temperature > conversion point relative humidity, the order of importance to aberration was regeneration temperature > conversion point relative humidity > drying temperature, the important influence order on SPC was dry temperature > regeneration temperature > conversion point relative humidity. The lower regeneration temperature resulted in the lower drying temperature, the higher rehydration ratio, and the lower relative humidity of the converse. The lower drying temperature, the smaller the relative humidity of the conversion point, and the lower chromatic aberration, and vice versa. The regeneration temperature, the drying temperature and the conversion point relative humidity to SPC showed a trend of low first and then high. When the regeneration temperature was 87 ℃, the drying temperature is 50 ℃, and the relative humidity of the conversion point was 45%. The rehydration ratio of Pleurotus eryngii was 4.028, the color difference was 22.89, SPC was 2633 kJ/kg, and the error between the predicted and absolute value was less than 6 percentage point. This study explored the critical dehumidification mechanism based on enthalpy point and improved the wheel dehumidification structure, and formulated the optimum dehumidification drying process of Pleurotus eryngii. The results can provide the basis for the design of wheel dehumidification and HPD combined dryer and the optimization of drying process.

       

    /

    返回文章
    返回