王冠, 霍丽丽, 赵立欣, 姚宗路, 孟海波. 秸秆类生物质原料筛分除杂试验及滚筒筛改进[J]. 农业工程学报, 2016, 32(13): 218-222. DOI: 10.11975/j.issn.1002-6819.2016.13.031
    引用本文: 王冠, 霍丽丽, 赵立欣, 姚宗路, 孟海波. 秸秆类生物质原料筛分除杂试验及滚筒筛改进[J]. 农业工程学报, 2016, 32(13): 218-222. DOI: 10.11975/j.issn.1002-6819.2016.13.031
    Wang Guan, Huo Lili, Zhao Lixin, Yao Zonglu, Meng Haibo. Screening of biomass straw materials and improvement of feedstock equipment[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2016, 32(13): 218-222. DOI: 10.11975/j.issn.1002-6819.2016.13.031
    Citation: Wang Guan, Huo Lili, Zhao Lixin, Yao Zonglu, Meng Haibo. Screening of biomass straw materials and improvement of feedstock equipment[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2016, 32(13): 218-222. DOI: 10.11975/j.issn.1002-6819.2016.13.031

    秸秆类生物质原料筛分除杂试验及滚筒筛改进

    Screening of biomass straw materials and improvement of feedstock equipment

    • 摘要: 为解决秸秆收获后小杂质去除问题,针对粒度在10 mm以下的玉米秸秆原料,利用样品分析筛,将原料分为9个粒度等级,之后进行热工特性测定、沉降试验。通过对不同粒度的玉米秸秆原料进行热工特性对比试验,分析灰尘等细颗粒物杂质在不同粒度原料中的比例及影响,发现粒度级别为0.2~0.33、<0.2 mm这2个物料尘土质量分数超过50%,而占总质量的百分含量仅为3.39%,故提出原料的最佳筛分粒度范围为<0.33 mm。优化改造筛分除杂装置,其最佳工况下的技术参数为:筛筒长1 000 mm,筛筒直径500 mm,筛筒倾斜角10°,转速34 r/min,筛网孔径0.33 mm。利用该装置,进行筛分工况确定试验、验证对比试验及经济分析,发现:使用筛网后的物料压块成型后,挥发分及热值有大幅度提升,灰分减少25.21%,大大降低了秸秆物料对成型机关键部件造成的磨损及对燃烧设备的结渣风险。其过筛后的压块成型燃料经济价值提高到563.5元/t,可提高收益6.91%。该文提出了一种适合中国生物质成型燃料大规模生产的筛分技术及配套装置,为生物质燃料清选工艺提供技术支撑,为秸秆的能源化利用提供重要参数依据。

       

      Abstract: Research and application on screening in China are mainly focused on coal, metallurgy, chemicals, building materials, and so on, only a few researches on the field of biomass energy. Biomass energy research is mainly focused on raw material obtaining and process, which can??t solve small impurity removal problems after straw harvest. Therefore, this article carried out the comparative tests of thermal characteristics on corn stover feedstock with different sizes, studied the impact of dust and other fine particulate matter on raw materials quality of corn stover, and analyzed the proportion of impurities with different particle sizes and their impacts on raw materials; the best sieve size range of raw materials was put forward so as to improve the purity of raw materials, and optimize the impurity screening equipment connecting between mill and molding machine. A series of experiments were done. At first, different corn straw materials, which were less than 10 mm particle size, should be divided into 9 size classes through sieve analysis; secondly, different size particles as material were utilized for thermal characteristic measurement and sedimentation experiments; thirdly, the proportion and the effect of fine particulate impurities in different corn straw materials were analyzed; at last, dust contents of 2 kinds of materials whose sizes were less than 0.2 and 0.33-0.2 mm exceeded 50%, and the quantity represented 3.39% of the total sum of such 2 kinds of materials. Therefore, the best suitable material size range is less than 0.33 mm compared to the other straw materials. Through the results of above analysis and a large number of reference documents, the sieve in this study were modified and processed from the former drum sieve. The structure of sieve also could be optimized, and its parameters were as follows: Sieve tube length was 1000 mm, screen cylinder diameter was 500 mm, screen cylinder inclination angle was 10°, rotation speed was 34 r/min, and sieve hole diameter was 0.33 mm. The comparative experiments and economic analysis based on this equipment were conducted. The results showed that the volatile matter and calorific value of pellets through the sieve process were improved significantly, and the ash content was reduced by 25.21%, which greatly declined the material??s molding wear risks to briquette machines and slagging risks to combustion devices. The economic value of this briquetting fuel increased to 563.5 yuan/t, which increased by 6.91%. The method that the sieve is considered as the first phase at the briquette forming can improve the purity of the material, and ensure the quality of fuel formed from corn straw. This thesis is expected to propose a screening technology and equipment suitable for Chinese large-scale production of biomass briquettes, to provide technical support for cleaning process, and to provide an important basis of parameters for the energy utilization of the straw.

       

    /

    返回文章
    返回